YellowGixxer

2005 636 wont start i just put it together...all the lights come on but when i press the start button nothing happends hte motor wont turn over click or nothing...what could i go check so i can narrow what it is down

nickalltogether

Try to push start it.

h_lowder636

battery dead..

YellowGixxer

the lights don't dim or anything when i press start shouldnt it dim if i press start because the battery is dead i can try to charge it tomorrow and see what happends

Dr_Rip_It

thats not going to work if it dont start by the starter you got something wrong..i would check your starter celonid see if you got power there thats the first thing that should work before everything else got to have the engine turning before you can check anything such as spark fuel ect..check the starter relay as well

nickalltogether

I thought this too. I let my battery run dead once on my 636 and it would just click under the front seat and not actually kick over.

Dr_Rip_It

use a meter and test the battery when you hit the key 12v that will tell you if its dead or not

zxcraig

right side clip on not pluged in all the way on the harness???

YellowGixxer

it is i checked

John LegionST

make sure battery is charged. check all fuses. check all connections. check ground wire!, the one that connects to the top of the block under the tank. check starter celenoid.

poni

yea enough energy to open the circuit relay but not enough to kick out the starter solenoid for the starter motor

Wheelie Ripper

I had the same problem, you have the controls pluged in the wrong connector. There are two connectors that that one will go into, switch it and you will be good to go.

YellowGixxer

well now it turns over and it just wont crank up ahhhhh

Towlieee

is your fuel pump priming?

if not, its just some wire not connected somewhere


it could be a MILLION things.. all the way from a split wire, a unpluged harness, maybe even a bad kill switch or something..

Or it could be as simple as a bad fuel pump or somthing


im guessing its a bad wire somewhere.. goodluck.. ONly thing you can really do is trace your entire wire harness making sure everything is hooked up and no wires are broke

Bubash

Did you check the big fuse on the left side under the seat?The one the battery terminals goes to. i had issues with mine blowing.

dpasch

well now thats you got it crnking do you get spark? check your plugs they might be really wet right now,id say throw the battery on a charger for a while, another one to check is your kickstand switch...unless you dont have the switch hooked up you need to make a loop back wire that will make it think the kickstand is up...thats possible...but there are a lot of possibilities first check to see if you get spark

YellowGixxer

it will fire up for like 2 seconds and die everytime even if i hold it wide open the motor ran perfect before it sat for 4 months..